高压物理学报

高压与加热协同处理对牛肌肉中蛋白酶活性的影响

PDF下载

马汉军 ¹ , 周光宏 ² , 余小领 ¹ , 高海燕 ¹ , 潘润淑 ¹ , D.A. Ledward ³

高压物理学报 | 2011,25(1): 89-96

收起

高压物理学报 | 2011 , 25 (1) : 89 -96

高压与加热协同处理对牛肌肉中蛋白酶活性的影响

全屏

马汉军¹, 周光宏², 余小领¹, 高海燕¹, 潘润淑¹, D.A. Ledward³

作者信息

^1.河南科技学院食品学院，河南新乡　453003

^2.南京农业大学教育部肉品加工与质量控制重点实验室，江苏南京　210095

^3.Department of Food Biosciences, University of Reading, P.O. Box 226, Whiteknights, Reading RG6 6AP, UK

作者简介:

马汉军（1965—），男，博士，教授，主要从事高压技术在肉类加工中的应用研究. E-mail：hjma@hist.edu.cn

Effects of Combined High Pressure and Thermal Treatment on Protease Activities in Beef Muscle

Han-Jun MA¹, Guang-Hong ZHOU², Xiao-Ling YU¹, Hai-Yan GAO¹, Run-Shu PAN¹, D.A. Ledward³

Affiliations

^1.School of Food Science, Henan Institute of Science and Technology, Xinxiang 453003, China

^2.Key Laboratory of Meat Processing and Quality Control, Ministry of Education, Nanjing Agricultural University, Nanjing 210095, China

^3.Department of Food Biosciences, University of Reading, P.O. Box 226, Whiteknights, Reading RG6 6AP, UK

出版时间: 2011-02-15

文章导航

摘要

收起

在不同温度（20~60 ℃）和压力（0.1~600 MPa）下处理20 min，对牛肌肉中蛋白酶活性的影响进行了研究。结果显示：室温下，随着处理压力的增加，酶的活力显著下降，而压力达400 MPa及以上时，酶的活力则没有明显变化，同时在pH值为3和7.5时酶的活性几乎完全丧失。200 MPa以下的压力处理使肌肉中游离氨基酸总量显著上升，压力继续升高，游离氨基酸含量增加的幅度随之降低。400 MPa及以上压力处理使胰蛋白酶对蛋白质的消化性增强。在40 ℃温度、200 MPa压力下的处理，酶的活性没有明显下降，氨基酸总量也未发生明显变化。随着压力的升高酶的活性逐渐丧失，600 MPa时，酶在pH值为7.5时几乎完全失活，氨基酸总量急剧下降。60 ℃温度下，部分酶仍具有一定活力，200 MPa没有造成酶活力的明显变化，然而游离氨基酸的含量则显著增加。600 MPa压力下几乎使所有酶丧失活力，游离氨基酸的含量也明显降低。40~60 ℃温度下的压力处理，胰蛋白酶对蛋白质的降解作用表现出相同的规律，200 MPa时与对应的处理温度相比没有明显变化，600 MPa时显著提高。实验结果显示，高压和温度结合处理能调节蛋白酶的活性，提高肉类品质。

关键词

高压 / 热处理 / 牛肌肉 / 蛋白酶活性

Abstract

收起

The effects of combined high pressure (0.1~600 MPa) and temperature (20~60 ℃) treatment for 20 min on beef protease activities were studied. The results showed that the protease activities decreased with increasing pressure up to 400 MPa at room temperature, after which there was no significant change of them. The content of free amino acid increased significantly at 200 MPa and then the increased speed decreased with the pressure increasing.400 MPa or higher pressure treatment at room temperature resulted in the increase of tryptic digestibility of protein in beef extract. There was no significant effect on protease activities and free amino acid content in beef after pressurized at 200 MPa, 40 ℃, but the protease was almost completely inactivated at pH 7.5 and free amino acid content reduced rapidly after treated at 600 MPa, 40 ℃. Part of protease activities survived in beef muscle when heated at 60 ℃. They did not change significantly when treated at 200 MPa, 60 ℃, but the free amino acid content increased obviously. Treatment of 600 MPa at 60 ℃ resulted in the inactivation of almost all the proteases and the free amino acid content also decreased markedly. The similar changes of tryptic digestibility of protein in beef extract were found when pressure applied at 40~60 ℃. 200 MPa treatment did not cause significant changes and 600 MPa treatment induced the tryptic digestibility of protein marked increase. These results suggested that high pressure treatment combined with heating could regulate proteases activities of beef and improve its quality.

Key words

high pressure / thermal treatment / beef muscle / protease activities

引用本文

马汉军, 周光宏, 余小领, 高海燕, 潘润淑, D.A. Ledward. 高压与加热协同处理对牛肌肉中蛋白酶活性的影响. 高压物理学报, 2011 , 25 (1) : 89 -96 .

Han-Jun MA, Guang-Hong ZHOU, Xiao-Ling YU, Hai-Yan GAO, Run-Shu PAN, D.A. Ledward. Effects of Combined High Pressure and Thermal Treatment on Protease Activities in Beef Muscle[J]. Chinese Journal of High Pressure Physics, 2011 , 25 (1) : 89 -96 .

基金

收起

“十一五”国家科技支撑计划项目(2006BAD05A03)
教育部留学回国人员科研启动基金

参考文献

收起

文献

收起

参考文献引证文献

排序方式：

[1]

Garriga M, Grèbol N, Aymerich M T, et al. Microbial Inactivation after High-Pressure Processing at 600 MPa in Commercial Meat Products over Its Shelf Life[J]. Innov Food Sci Emerg Technol, 2004, 5(4): 451-457.

[2]

Rubio B, Martínez B, García-Cachán M D. Effect of High Pressure Preservation on the Quality of Dry Cured Beef “Cecina de Leon”[J]. Innov Food Sci Emerg Technol, 2007, (8): 102-110.

[3]

Cheftel J C, Culioli J. Effects of High Pressure on Meat: A Review[J]. Meat Sci, 1997, 46(3): 211-236.

[4]

Sikes A L, Tobin A B, Tume R K. Use of High Pressure to Reduce Cook Loss and Improve Texture of Low-Salt Beef Sausage Batters[J]. Innov Food Sci Emerg Technol, 2009, 10(4): 405-412.

[5]

Pedro H A L, Alfaia A J, Marques J, et al. Design of an Immobilized Enzyme System for Naringin Hydrolysis at High-Pressure[J]. Enzyme Microb Tech, 2007, 40(3): 442-446.

[6]

Cheftel J C. Review: High-Pressure, Microbial Inactivation and Food Preservation[J]. Food Sci Technol Intern, 1995, 1(2-3): 75-90.

[7]

Michael J, Eisenmengera, Reyes-De-Corcuera J I. High Hydrostatic Pressure Increased Stability and Activity of Immobilized Lipase in Hexane[J]. Enzyme Microb Tech, 2009, 45(2): 118-125.

[8]

Beilken S L, Macfarlane J J, Jones P N. Effect of High Pressure During Heat Treatment on the Warner-Bratzler Shear Force Values of Selected Beef Muscles[J]. J Food Sci, 1990, 55(1): 15-18.

[9]

Jung S, Ghoul M, de Lamballerie-Anton M. Changes in Lysosomal Enzyme Activities and Shear Values of High Pressure Treated Meat During Ageing[J]. Meat Sci, 2000, 56(3): 239-246.

[10]

Lamballerie-Anton M D, Enitiaa Taylor R G, Culioli J. High Pressure Processing of Meat[A]//Kerry J, Ledward D. Meat Processing: Improving Quality[C]. Woodhead: CRC Press Cambridge, 2002: 314-331.

[11]

Zamri A I, Ledward D A, Frazier R A. Effect of Combined Heat and High-Pressure Treatments on the Texture of Chicken Breast Muscle (Pectoralis Fundus)[J]. J Agric Food Chem, 2006, 54(8): 2992-2996.

[12]

Ma H J, Ledward D A. High Pressure/Thermal Treatment Effects on the Texture of Beef Muscle[J]. Meat Sci, 2004, 68(3): 347-355.

[13]

Johnston D E. High Pressure-A New Dimension to Food Processing[J]. Chem Indus, 1994, (13): 499-501.

[14]

Ohmori T, Shigehisa T, Taji S, et al. Effect of High Pressure on the Protease Activities in Meat[J]. Agricultural and Biological Chemistry, 1991, 55(2): 357-361.

[15]

Ohmori T, Shigehisa T, Taji S, et al. Biochemical Effects of High Hydrostatic Pressure on the Lysosome and Proteases Involved in It[J]. Biosci, Biotech, Biochem, 1992, 56(8): 1285-1288.

[16]

Homma N, Ikeuchi Y, Suzuki A. Effects of High Pressure Treatment on the Proteolytic Enzymes in Meat[J]. Meat Sci, 1994, 38(2): 219-228.

[17]

Homma N, Ikeuchi Y, Suzuki A. Levels of Calpain and Calpastatin in Meat Subjected to High Pressure[J]. Meat Sci, 1995, 41(3): 251-260.

[18]

Jung S, Ghoul M, de Lamballerie-Anton M. Changes in Lysosomal Enzyme Activities and Shear Values of High Pressure Treated Meat During Ageing[J]. Meat Sci, 2000, 56(3): 239-246.

[19]

Zeece M G, Woods T L, Keen M A. Role of Proteinase and Inhibitors in Post-Mortem Muscle Protein Degradation[J]. Reciprocal Meat Conference Proceedings, 1992, 45: 51-61.

[20]

Hughes M C, Healy Á, McSweeney P L H. Proteolytic Specificity of Cathepsin D on Bovine F-Actin[J]. Meat Sci, 2000, 56(2): 165-172.

[21]

Zeece M G, Katoh K. Cathepsin D and Its Effects on Myofibrillar Proteins: A Review[J]. J Food Biochem, 1989, 13(3): 157-178.

[22]

Goll D E, Otsuka Y, Nagainis P A. Role of Muscle Proteins in Maintenance of Muscle Integrity and Mass[J]. J Food Biochem, 1983, 7(3): 137-177.

[23]

Koohmaraie M. Muscle Proteinases and Meat Aging[J]. Meat Sci, 1994, 36(1-2): 93-104.

[24]

Elgasim E A, Kennick W H. Effect of High Hydrostatic Pressure on Meat Microstructure[J]. Food Microstructure, 1982, 1: 75-82.

[25]

Elgasim E A, Kennick W H, Anglemier A F, et al. Effect of Prerigor Pressurization on Bovine Lysosomal Enzyme Activity[J]. Food Microstruct, 1983, 2: 91-97.

[26]

Kubo T, Gerelt B, Han G D, et al. Changes in Immunoelectron Microscopic Localization of Cathepsin D in Muscle Induced by Conditioning or High-Pressure Treatment[J]. Meat Sci, 2002, 61(4): 415-418.

[27]

Angsupanich K, Ledward D A. High Pressure Treatment Effects on Cod (Gadus morhua) Muscle[J]. Food Chem, 1998, 63(1): 39-50.

[28]

Shiono T, Hayasaka S, Mizuno K. Effect of Temperature and pH on Release of Enzymes from Lysosomes of the Bovine Retinal Pigment Epithelium in Vitro[J]. Exp Eye Res, 1983, 36(6): 871-876.

[29]

Sentandreu M A, Coulis G, Ouali A. Role of Muscle Endopeptidases and Their Inhibitors in Meat Tenderness[J]. Trends Food Sci Tech, 2002, 13(12): 400-421.

[30]

Balny C, Masson P. Effects of High Pressure on Proteins[J]. Food Rev Int, 1993, 9(4): 611-628.

[31]

Fernández-Martín F, Fernández P, Carballo J, et al. Pressure/Heat Combinations on Pork Meat Batters: Protein Thermal Behavior and Product Rheological Properties[J]. J Agric Food Chem, 1997, 45(11): 4440-4445.

[32]

Macfarlane J J, Morton D J. Effects of Pressure Treatment on the Ultrastructure of Striated Muscle[J]. Meat Sci, 1978, 2(4): 281-288.

[33]

Suzuki A, Watanabe M, Iwamura K, et al. Effect of High Pressure Treatment on the Ultrastructure and Myofibrillar Protein of Beef Skeletal Muscle[J]. Agric Biolog Chem, 1990, 54(12): 3085-3091.

2011年第25卷第1期

PDF下载

引用本文

BibTeX

文章信息

接收时间：2009-08-20
首发时间：2026-11-02
出版时间：2011-02-15

补充材料

相关文章

文章信息

作者

出版历史

收稿日期：2009-08-20
修回日期：2009-10-14

基金

“十一五”国家科技支撑计划项目(2006BAD05A03)

教育部留学回国人员科研启动基金

作者信息

^1.河南科技学院食品学院，河南新乡　453003

^2.南京农业大学教育部肉品加工与质量控制重点实验室，江苏南京　210095

^3.Department of Food Biosciences, University of Reading, P.O. Box 226, Whiteknights, Reading RG6 6AP, UK

参考文献

分享链接

https://castjournals.cast.org.cn/joweb/gywlxb/CN/1324026846102298960

分享至

全文二维码

扫描看全文

引用本文

BibTeX

本文的引用情况

2种不同金属材料的力学参数

科 Family	属数 Number of genus	种数 Number of species	占总种数比例 Percentage of total species (%)	属 Genus	种数 Number of species	占总种数比例 Percentage of total species (%)
鹅膏菌科Amanitaceae	2	11	5.26	鹅膏菌属 Amanita	10	4.78
小菇科 Mycenaceae	2	12	5.74	丝盖伞属 Inocybe	5	2.39
多孔菌科 Polyporaceae	8	14	6.70	蜡蘑属 Laccaria	5	2.39
红菇科 Russulaceae	3	23	11.00	小皮伞属 Marasmius	6	2.87
				小菇属 Mycena	11	5.26
				光柄菇属 Pluteus	5	2.39
				红菇属 Russula	17	8.13
				栓菌属 Trametes	5	2.39

关闭全屏

BibTeX
EndNote
RefWorks
TxT