热带作物学报

不同稳定剂对天然胶乳胶膜物理机械性能的影响

PDF下载

赵立广 ¹^,²^,³ , 李建伟 ¹^,³ , 宋亚忠 ¹^,² , 丁丽 ¹^,³ , 戴拓 ¹^,³ , 黄红海 ¹^,³ , 王岳坤 ¹^,² , 赵涛 ¹^,⁴ , 桂红星 ¹^,²^,^*

热带作物学报 | 采后处理与质量安全 2023,44(6): 1237-1245

收起

热带作物学报 | 采后处理与质量安全 2023, 44(6): 1237-1245

不同稳定剂对天然胶乳胶膜物理机械性能的影响

全屏

赵立广¹^,²^,³, 李建伟¹^,³, 宋亚忠¹^,², 丁丽¹^,³, 戴拓¹^,³, 黄红海¹^,³, 王岳坤¹^,², 赵涛¹^,⁴, 桂红星¹^,²^,^*

作者信息

^1.中国热带农业科学院橡胶研究所，海南海口　571101

^2.海南省天然橡胶栽培与加工工程研究中心，海南海口　571101

^3.海南省高性能天然橡胶材料工程重点实验室，海南海口　571101

^4.青岛科技大学，山东青岛　266061

赵立广（1990—），男，硕士，助理研究员，研究方向：天然橡胶加工技术。

通讯作者:

^* 桂红星（GUIHongxing），E-mail: guihongxing@263.net。

Effects of Different Stabilizers on the Properties of Natural Rubber Latex Films

Liguang ZHAO¹^,²^,³, Jianwei LI¹^,³, Yazhong SONG¹^,², Li DING¹^,³, Tuo DAI¹^,³, Honghai HUANG¹^,³, Yuekun WANG¹^,², Tao ZHAO¹^,⁴, Hongxing GUI¹^,²^,^*

Affiliations

^1.Rubber Research Institute, Chinese Academy of Tropical Agricultural Sciences, Haikou, Hainan 571101, China

^2.Hainan Provincial Natural Rubber Cultivation and Processing Engineering Research Center, Haikou, Hainan 571101, China

^3.Hainan Provincial Key Laboratory of High-Performance Natural Rubber Materials Engineering, Haikou, Hainan 571101, China

^4.Qingdao University of Science and Technology, Qingdao, Shandong 266061, China

出版时间: 2023-06-25 doi: 10.3969/j.issn.1000-2561.2023.06.017

文章导航

摘要

收起

天然胶乳稳定剂不仅会影响胶乳的胶体稳定性，对胶膜性能也具有显著影响。本研究选用氢氧化钾（KOH）、氨、十二烷基硫酸钠（SDS）和月桂酸钾4种稳定剂添加到浓缩胶乳中，并制备预硫化配合胶乳，研究4种稳定剂对浓缩胶乳成膜性能、胶膜硫化特性及物理机械性能的影响。结果表明：4种稳定剂中对浓缩胶乳胶膜性能影响最大的是KOH，KOH会提高干胶膜的门尼粘度；降低干胶膜收缩率、拉伸强度、定伸应力、断裂伸长率、撕裂强度和硬度等力学性能；同时缩短硫化胶膜的t₁₀、t₅₀和t₉₀时间，转矩差值先升后降，定伸应力有所提升，但拉伸强度、断裂伸长率和硬度均会降低，而撕裂强度呈先升后降的趋势。随着氨用量的提高，干胶膜收缩率、拉伸强度、断裂伸长率和撕裂强度均呈先升后降的趋势；硫化胶膜t₉₀和胶膜收缩率有所升高；拉伸强度、定伸应力同样存在先升后降的趋势。随着SDS用量的提高，浓缩胶乳干胶膜拉伸强度存在先降后升的趋势；硫化胶膜的转矩差值有一定程度的升高；t₅₀和t₉₀比较稳定，并在SDS用量超过0.3%后明显上升，即硫化速度降低；硫化胶膜收缩率快速下降，下降幅度较大。随着月桂酸钾用量的提高，干胶膜门尼粘度和收缩率下降幅度很大；断裂伸长率和撕裂强度有一定提升。硫化胶膜的转矩差值升高幅度最大；胶膜收缩率明显降低，撕裂强度呈先升后降的趋势，其他指标稳定，变化幅度较小。

关键词

天然胶乳 / 稳定剂 / 物理机械性能 / 硫化特性 / 收缩率

Abstract

收起

In this study, four stabilizers including potassium hydroxide (KOH), ammonia, sodium dodecyl sulfate (SDS) and potassium laurate were added to concentrated natural rubber latex (CNRL). The performance of the CNRL film was most affected by the amount of KOH. With the increase of KOH content, the Mooney viscosity of the film increased and the shrinkage rate decreased. The tensile strength, tensile stress, elongation at break, tear strength and hardness all decreased rapidly. With the increase dosage of potassium laurate, the Mooney viscosity and the shrinkage rate of the raw rubber film decreased to a certain extent. The tensile strength had a tendency to increase first and then decrease. With the increase of ammonia consumption, there was also a trend of first rising and then falling. More dosage of sodium dodecyl sulfate (SDS) would lead to lower tear strength of the raw rubber film. The performance of the vulcanizate film was also most affected by the amount of KOH. With the increase of KOH dosage, the M_L and M_H of the vulcanizate film would increase. The t₁₀, t₅₀ and t₉₀ would be shortened, and the film shrinkage was reduced. In addition, the tensile strength and elongation at break of the rubber film decreased. The tensile stress and tear strength had a trend of increasing first and then decreasing. As the amount of ammonia increased, the t₉₀ of the vulcanizate film would increase. The shrinkage rate of the film increasesd, and the tensile stress first increased and then decreased. With the increase of the amount of SDS, the t₉₀ of the vulcanizate film would be prolonged and the film shrinkage was reduced. With the increase of potassium laurate dosage, the M_L and M_H of the vulcanizate film would increase, the film shrinkage was reduced, and the tear strength showed a trend of increasing first and then decreasing. It could be seen from the hardness change that the film would become soft after adding KOH and the hardness would be greatly reduced. The Mooney viscosity of the film was greatly improved. After the addition of potassium laurate, the Mooney viscosity of the film decreased significantly, but the hardness of the film did not change much. From the perspective of vulcanization, after adding KOH, the vulcanization degree of the rubber film increased, and the vulcanization time decreased. KOH had a certain promotion and promotion effect on the vulcanization degree of the film. However, combined with the mechanical properties of the vulcanized film. The tensile stress of the film increased after adding KOH, but the tensile strength, tear strength and elongation were significantly reduced. However, the film strength changed little when the other three stabilizers were added.

Key words

natural rubber latex / stabilizer / vulcanization characteristics / film properties / mechanical properties

引用本文

赵立广, 李建伟, 宋亚忠, 丁丽, 戴拓, 黄红海, 王岳坤, 赵涛, 桂红星. 不同稳定剂对天然胶乳胶膜物理机械性能的影响. 热带作物学报, 2023 , 44 (6) : 1237 -1245 . DOI: 10.3969/j.issn.1000-2561.2023.06.017

Liguang ZHAO, Jianwei LI, Yazhong SONG, Li DING, Tuo DAI, Honghai HUANG, Yuekun WANG, Tao ZHAO, Hongxing GUI. Effects of Different Stabilizers on the Properties of Natural Rubber Latex Films[J]. Chinese Journal of Tropical Crops, 2023 , 44 (6) : 1237 -1245 . DOI: 10.3969/j.issn.1000-2561.2023.06.017

基金

收起

海南省重大科技计划项目(ZDKJ2021004)
现代农业产业技术体系建设专项(CARS-33-GJ1)

参考文献

收起

2023年第44卷第6期

PDF下载

引用本文

BibTeX

文章信息

doi: 10.3969/j.issn.1000-2561.2023.06.017

接收时间：2022-07-01
首发时间：2026-03-05
出版时间：2023-06-25

补充材料

相关文章

文章信息

作者

出版历史

收稿日期：2022-07-01
修回日期：2022-10-17

基金

海南省重大科技计划项目(ZDKJ2021004)

现代农业产业技术体系建设专项(CARS-33-GJ1)

作者信息

^1.中国热带农业科学院橡胶研究所，海南海口　571101

^2.海南省天然橡胶栽培与加工工程研究中心，海南海口　571101

^3.海南省高性能天然橡胶材料工程重点实验室，海南海口　571101

^4.青岛科技大学，山东青岛　266061

通讯作者:

^* 桂红星（GUIHongxing），E-mail: guihongxing@263.net。

参考文献

分享链接

https://castjournals.cast.org.cn/joweb/rdzwxb/CN/10.3969/j.issn.1000-2561.2023.06.017

分享至

全文二维码

扫描看全文

引用本文

BibTeX

本文的引用情况

2种不同金属材料的力学参数

科 Family	属数 Number of genus	种数 Number of species	占总种数比例 Percentage of total species (%)	属 Genus	种数 Number of species	占总种数比例 Percentage of total species (%)
鹅膏菌科Amanitaceae	2	11	5.26	鹅膏菌属 Amanita	10	4.78
小菇科 Mycenaceae	2	12	5.74	丝盖伞属 Inocybe	5	2.39
多孔菌科 Polyporaceae	8	14	6.70	蜡蘑属 Laccaria	5	2.39
红菇科 Russulaceae	3	23	11.00	小皮伞属 Marasmius	6	2.87
				小菇属 Mycena	11	5.26
				光柄菇属 Pluteus	5	2.39
				红菇属 Russula	17	8.13
				栓菌属 Trametes	5	2.39

关闭全屏

BibTeX
EndNote
RefWorks
TxT