硅酸盐学报

三乙醇胺络合作用下钢渣的水化特性

PDF下载

常磊 ¹^,² , 黄炳银 ¹ , 王剑锋 ¹ , 刘辉 ¹ , 王亚丽 ¹ , 崔素萍 ¹^,²

硅酸盐学报 | 研究论文 2024,52(5): 1621-1630

收起

硅酸盐学报 |研究论文 2024 , 52 (5) : 1621 -1630

三乙醇胺络合作用下钢渣的水化特性

全屏

常磊¹^,², 黄炳银¹, 王剑锋¹, 刘辉¹, 王亚丽¹, 崔素萍¹^,²

作者信息

^1．北京工业大学材料科学与工程学院，北京 100124

^2．北京工业大学碳中和未来技术学院，北京 100124

通讯作者:

崔素萍（1964—），女，博士，教授。

作者简介:

常磊（1999—），男，博士研究生。

Hydration Characteristics of Steel Slag Under Complexing of Triethanolamine

Lei CHANG¹^,², Bingyin HUANG¹, Jianfeng WANG¹, Hui LIU¹, Yali WANG¹, Suping CUI¹^,²

Affiliations

^1.College of Materials Science and Engineering, Beijing University of Technology, Beijing 100124, China

^2.College of Carbon Neutrality Future Technology, Beijing University of Technology, Beijing 100124, China

Corresponding Author:

CUI Suping (1964-), female, Ph.D., Professor. E-mail: cuisuping@bjut.edu.cn

CHANG Lei (1999-), male, Doctorial candidate. E-mail: Changlei0127@outlook.com

出版时间: 2024-05-20 doi: 10.14062/j.issn.0454-5648.20230720

文章导航

摘要

收起

三乙醇胺（TEA）作为外加剂常用于提高钢渣胶凝活性，但目前关于TEA对钢渣水化的研究仍集中在钢渣-水泥复合体系，难以明确TEA对钢渣水化特性的影响。本工作将TEA引入纯钢渣体系，通过抗压强度、水化热、热重、物相分析、络合能力测定和溶解特性分析来表征TEA络合作用下纯钢渣的水化特性。结果表明：TEA显著提高了硬化钢渣浆体早期及后期抗压强度，主要原因是TEA促进了钢渣中铝相（C₃A、C₁₂A₇）和铁相（C₂F）的水化及其与CaCO₃之间的反应，生成了对抗压强度有利的单碳型水化碳铝酸盐[]，从而提高了钢渣浆体的水化程度。TEA对水化的促进与TEA的络合作用有关，TEA可以与Ca²⁺、Al³⁺、Fe³⁺ 3种金属离子络合，在一定范围内（TEA与金属离子摩尔比小于等于1时），TEA与金属离子间的络合能力从强到弱依次为Fe³⁺、Al³⁺、Ca²⁺。TEA通过络合作用促进了钢渣的溶解，从而促进了钢渣的水化。

关键词

钢渣 / 三乙醇胺 / 络合 / 水化

Abstract

收起

Introduction

Steel slag is a solid waste produced from steelmaking, which has a potential cementitious activity. However, its cementitious activity is much lower than that of Portland cement. Mechanical grinding, acid activation, alkali activation, high-temperature curing, modification/reconstruction and organic activation methods are commonly used to improve the hydraulic activity of steel slag. Triethanolamine is commonly used as an organic admixture to improve cementitious activity of steel slag. The existing research on the hydration of TEA on steel slag still focuses on a steel slag-cement composite system, in which the proportion of cement is higher and the hydration rate is faster, so the results obtained are related to cement hydration, and it is difficult to characterize the effect of TEA on steel slag. It is thus necessary to investigate the hydration of pure steel slag in the presence of triethanolamine. In this paper, the hydration characteristics of pure steel slag under the complexation of TEA were characterized by compressive strength, heat of hydration, thermogravimetry, phase analysis, complexation ability and dissolution characteristics as well.

Methods

The compressive strength of hardened steel slag paste was tested. In this work, the hydration characteristics of steel slag were investigated at different TEA concentrations, and the concentrations selected were 0, 500, 1 000 mg/L and 2 000 mg/L. A mass ratio of TEA solution to steel slag was kept at 0.35. The size of test block was 20 mm×20 mm×20 mm, and the curing age was 3, 7 d and 28 d. In the process of compressive strength testing, the test entrance force was set to be 200 N, and the pressure was applied by force control, and the pressure rate was 100 N/s. After the compressive strength was tested, the specimens were smashed (<5 mm) and the center portion of the specimens was immersed in an isopropanol solution to terminate hydration, and the terminated hydrated steel slag pieces were dried in a vacuum drying oven at 40 ℃. After drying, steel slag pieces were ground and sieved through a 200 mesh (74 μm) sieve. A portion of steel slag powder was taken for thermogravimetric analysis and X-ray diffraction (XRD).

The hydration heat of steel slag paste was determined using calorimetry, and the exothermic process of hydration was recorded from the addition of water or TEA solution for 72 h. The TEA solution concentration and its ratio to steel slag both were consistent with the tests of compressive strength. The complexation ability of TEA with different metal ions was determined by a conductivity method. The complexation ability of TEA with metal ions was characterized via continuously adding TEA to a solution of metal ions at the same concentration and recording the conductivity data. The conductivity method was also used to characterize the dissolution process of steel slag in the presence or absence of TEA. The conductivity of solution without steel slag was the initial value, which was measured from the contact of steel slag with water and recorded continuously for 25 min.

Results and discussion

The compressive strength of hardened steel slag paste with TEA is higher than that of the blank group without TEA at each age. This indicates that TEA can simultaneously increase the early and late compressive strength of hardened steel slag paste, and this strengthening effect increases with the increase of TEA concentration. When TEA is in steel slag paste, the diffraction peaks of monocarboaluminate (Mc) appear, and the diffraction peaks of C₂F gradually become weaker. This indicates that TEA can promote the formation of Mc, and the content of CaCO₃ is fixed at different TEA concentrations, so it can be inferred that TEA promotes the formation of Mc via promoting the hydration of aluminum phases. Meanwhile, TEA promotes the hydration of C₂F, and [Fe] in C₂F can participate in the formation of Mc as a substitutional ion of [Al] to form (). The heat of hydration and thermogravimetric tests further indicate that TEA can promote the hydration of aluminate and ferrate phases. The hydration degree is enhanced by the formation of a large amount of Mc. The increase in hydration degree ultimately leads to an increase in compressive strength.

The promotion of Mc formation by TEA is related to its complexation. When the concentration of TEA is less than or equal to 0.05 mol/L, i.e., the molar ratio of TEA to metal ions is less than or equal to 1, the complexation ability of TEA on Fe³⁺ is stronger than that of Al³⁺ and Ca²⁺. When the concentration of TEA is greater than or equal to 0.05 mol/L, i.e., the molar ratio of TEA to metal ions is greater than or equal to 1, the complexation ability of TEA on Al³⁺ is stronger than that of Fe³⁺ and Ca²⁺. TEA promotes the dissolution of mineral phase in steel slag through complexation. The free-moving metal ions and the complexed metal ions in liquid phase of steel slag can simultaneously participate in the precipitation reaction of hydration product, producing a large amount of Mc, and thus improving the early and late hydration of steel slag paste, which in turn manifests itself as an increase in the compressive strength.

Conclusions

The complexation ability between TEA and metal ions and effect of TEA complexation on dissolution and hydration characteristics of pure steel slag were investigated. TEA significantly increased the early and late compressive strength of hardened steel slag paste. The main reason for the increase in compressive strength of hardened steel slag paste was that TEA improved the hydration degree of steel slag paste in early and late stages. TEA promoted the hydration of aluminate phases (C₃A, C₁₂A₇) and ferrate phase (C₂F), and through the interaction with carbonate, a large number of () were formed, and the formation of such hydration products was the main reason for the improvement of the hydration degree and the compressive strength of steel slag paste. The large formation of Mc was related to the complexation and solubilization effect of TEA. TEA could complex with Ca²⁺, Al³⁺ and Fe³⁺, and the complexation of TEA promoted dissolution of steel slag and formation of metal ions that could participate in the precipitation reaction, thus promoting the hydration of steel slag paste.

Key words

steel slag / triethanolamine / complexation / hydration

引用本文

常磊, 黄炳银, 王剑锋, 刘辉, 王亚丽, 崔素萍. 三乙醇胺络合作用下钢渣的水化特性. 硅酸盐学报, 2024 , 52 (5) : 1621 -1630 . DOI: 10.14062/j.issn.0454-5648.20230720

Lei CHANG, Bingyin HUANG, Jianfeng WANG, Hui LIU, Yali WANG, Suping CUI. Hydration Characteristics of Steel Slag Under Complexing of Triethanolamine[J]. Journal of the Chinese Ceramic Society, 2024 , 52 (5) : 1621 -1630 . DOI: 10.14062/j.issn.0454-5648.20230720

基金

收起

北京市科技计划项目(Z221100007522002)
国家自然科学基金(52202017)

参考文献

收起

文献

收起

参考文献引证文献

排序方式：

2024年第52卷第5期

PDF下载

引用本文

BibTeX

文章信息

doi: 10.14062/j.issn.0454-5648.20230720

接收时间：2023-09-16
首发时间：2026-10-22
出版时间：2024-05-20

补充材料

相关文章

文章信息

作者

出版历史

收稿日期：2023-09-16
修回日期：2023-10-12

基金

北京市科技计划项目(Z221100007522002)

国家自然科学基金(52202017)

作者信息

^1．北京工业大学材料科学与工程学院，北京 100124

^2．北京工业大学碳中和未来技术学院，北京 100124

通讯作者:

崔素萍（1964—），女，博士，教授。

参考文献

分享链接

https://castjournals.cast.org.cn/joweb/gsyxb/CN/10.14062/j.issn.0454-5648.20230720

分享至

全文二维码

扫描看全文

引用本文

BibTeX

本文的引用情况

2种不同金属材料的力学参数

科 Family	属数 Number of genus	种数 Number of species	占总种数比例 Percentage of total species (%)	属 Genus	种数 Number of species	占总种数比例 Percentage of total species (%)
鹅膏菌科Amanitaceae	2	11	5.26	鹅膏菌属 Amanita	10	4.78
小菇科 Mycenaceae	2	12	5.74	丝盖伞属 Inocybe	5	2.39
多孔菌科 Polyporaceae	8	14	6.70	蜡蘑属 Laccaria	5	2.39
红菇科 Russulaceae	3	23	11.00	小皮伞属 Marasmius	6	2.87
				小菇属 Mycena	11	5.26
				光柄菇属 Pluteus	5	2.39
				红菇属 Russula	17	8.13
				栓菌属 Trametes	5	2.39

关闭全屏

BibTeX
EndNote
RefWorks
TxT