硅酸盐学报

单宁酸强化二维蒙脱石薄膜锂镁高效分离及其机理

PDF下载

孙宇鹏 ¹ , 赵云良 ¹^,² , 高仁波 ¹ , 万骞 ³ , 陈立才 ¹ , 张鑫 ¹ , 张婷婷 ¹

硅酸盐学报 | 非金属矿清洁高效利用专题—研究论文 2025,53(12): 3624-3633

收起

硅酸盐学报 |非金属矿清洁高效利用专题—研究论文 2025 , 53 (12) : 3624 -3633

单宁酸强化二维蒙脱石薄膜锂镁高效分离及其机理

全屏

孙宇鹏¹, 赵云良¹^,², 高仁波¹, 万骞³, 陈立才¹, 张鑫¹, 张婷婷¹

作者信息

^1．武汉理工大学资源与环境工程学院，武汉 430070

^2．武汉科莱烯科技有限公司，武汉 430223

^3．武汉科技大学资源与环境工程学院，武汉 430081

通讯作者:

赵云良（1987—），男，博士，教授。

作者简介:

孙宇鹏（2000—），男，硕士研究生。

Enhancement and Mechanism of Tannic Acid Modification on Separation of Lithium and Magnesium in a Two-Dimensional Montmorillonite Membrane

Yupeng SUN¹, Yunliang ZHAO¹^,², Renbo GAO¹, Qian WAN³, Licai CHEN¹, Xin ZHANG¹, Tingting ZHANG¹

Affiliations

^1.School of Resources and Environmental Engineering, Wuhan University of Technology, Wuhan 430070, China

^2.Wuhan Clayene Technology Co., Ltd., Wuhan 430223, China

^3.School of Resources and Environmental Engineering, Wuhan University of Science and Technology, Wuhan 430081, China

Corresponding Author:

ZHAO Yunliang (1987-), male, Ph.D., Professor. E-mail: zyl286@whut.edu.cn

SUN Yupeng (2000-), male, Master candidate. E-mail: 302647@whut.edu.cn

出版时间: 2025-12-20 doi: 10.14062/j.issn.0454-5648.20250414

文章导航

摘要

收起

盐湖提锂是保障中国锂资源安全的重要途径，但高性能盐湖提锂薄膜的设计却面临严峻挑战。论文提出以天然负电性的单宁酸（TA）改性二维蒙脱石薄膜，实现其高效锂镁分离。薄膜的Mg²⁺截留率接近100%，Li⁺截留率为-9%，即Li⁺实现富集，水通量为22.5 L·m^-2·h^-1，相较未改性的二维蒙脱石薄膜水通量提升49%，并且在120 h的运行时间内分离性能基本稳定。机理研究发现，TA的酚羟基与蒙脱石纳米片端面的铝羟基通过氢键相连，增加了薄膜表面孔隙的负电位点，使其可以吸附更多的聚乙烯亚胺（PEI）来强化界面聚合反应，从而降低薄膜的表面孔径，提高薄膜的Mg²⁺截留率；此外，电化学测试研究发现，TA的引入可以降低二维蒙脱石薄膜的Li⁺传输阻力，本工作对于高性能盐湖提锂薄膜的设计与研究提供了新的思路。

关键词

蒙脱石 / 二维纳米片 / 分离膜 / 锂镁分离 / 单宁酸

Abstract

收起

Introduction

Lithium extraction from salt lake is essential for ensuring lithium resource security in China, but the design of high-performance lithium extraction membranes from salt lake faces significant challenges. Two-dimensional (2D) membranes with oriented nanochannels consist of 2D nanosheets stacked layer by layer. These membranes have nanoscale channel heights that can be precisely controlled at the sub-nanometer level, making them suitable for the selective separation of lithium (Li) and magnesium (Mg) ions. Typically, the Li⁺/Mg²⁺ selectivity of membrane requires surface modification with positive charge due to the inherent charge differences between Li⁺ and Mg²⁺. Interfacial polymerization (IP) is commonly used for the membrane surface modification. However, the excessive IP reactions can result in excess positive charge, reducing the Li⁺ transport efficiency. Therefore, the design and development of 2D selective membranes with optimized IP reactions while maintaining high lithium-ion transport efficiency is of great significance. Layered montmorillonite (MMT) mineral has natural layered structure and it can be easily exfoliated into 2D nanosheets, which are ideal building blocks for the assembly of 2D membranes. In this work, hydrophilic tannic acid (TA) with negative charge is applied to modify the surface of 2D MMT nanosheets, enabling an enhanced Mg²⁺ rejection and suppressed transport resistance of Li⁺ transport. Our results provide a valuable reference for the design and fabrication of novel 2D membranes with high Li⁺/Mg²⁺ selectivity.

Methods

The MMT nanosheet suspension was prepared by ultrasonic exfoliation. The suspension mixed with auxiliary membrane-forming agents were scraped coated and dried on a substrate to obtain 2D MMT membranes. For the preparation of TA-modified membranes, TA was added to the MMT nanosheet suspension and coated on substrate using the same protocol. As-prepared membranes were then used for IP reactions. The membranes were first immersed in a PEI solution 45 s. After washing and drying, the membranes were then immersed in a TMC solution for 15 s. As-obtained membranes were dried in an oven for subsequent nanofiltration and characterizations. The morphology and surface roughness of the 2D MMT membranes were characterized by a JSM 7100F scanning electron microscope (SEM) and a Multi Mode 8 atomic force microscope (AFM). The surface chemical analyses was conducted by a K-Alpha X-ray photoelectron spectroscopy (XPS). The alignment and orientation of internal 2D nanochannels of the MMT membrane were analyzed by a D8 ADVANCE X-ray diffractometer (XRD) and Xeuss 2.0 X-ray wide-angle diffractometer (WAXS).

Results and discussion

According to the morphological and structural characterizations, the 2D membranes fabricated with bare 2D MMT nanosheets exhibit a well-oriented 2D nanochannel structure. The alignment of TA-modified 2D MMT nanosheets were unaffected during IP reaction, generating a well-preserved membrane structure according to the cross-sectional SEM and WAXS.

With the increasing content of TA, the rejection of Mg²⁺ increased simultaneously and reached up to almost 100% with 1.5% addition of TA. A negative Li⁺ rejection was also achieved correspondingly. However, excess amount of TA resulted in a deterioration of both the rejection of Mg²⁺ and selective transport of Li⁺. In addition to the selectivity, the TA modification significantly promoted the membrane flux up to 22.5 L·m^-2·h^-1, which was 49% higher than that of bare MMT membrane. The TA modified MMT membrane exhibited consistently high Mg²⁺ rejection under various feed conditions and high performance stability during a 120 h long-term operation.

The enhancement in membrane selectivity and flux through TA modification was due to the promoted IP reaction and a narrowed pore size distribution, validated by XPS measurements and molecular weight cut off (MWCO) tests. Furthermore, the role of TA in membrane formation was revealed by AFM and XPS measurements. The TA molecules can connect the adjacent MMT nanosheets via hydrogen bonding between its phenolic hydroxyl groups and the Al-OH on edge surface of MMT. The negative charge on TA provides more anchoring site for the PEI monomers, thereby promoting the IP reaction. Energy barrier calculated by Arrhenius equation further validated that the TA modification can reduce the Li⁺ transport resistance from 20.91 kJ·mol^-1 to 18.38 kJ·mol^-1 in the 2D nanochannels.

Conclusions

In this work, a TA-modification method was applied to enhance the separation performance of a 2D MMT membrane system. The Mg²⁺ rejection of the modified MMT membrane with optimized TA content reached almost 100%, with a corresponding negative Li⁺ rejection of -9%. The membrane flux was 22.5 L·m^-2·h^-1, after TA modification, which was 49% higher than that of bare MMT membrane. Moreover, the TA-modified membranes exhibited consistently high Mg²⁺/Li⁺ selectivity and flux under various feed conditions and excellent stability during long-term operation.

Topographical and surface chemical characterizations revealed the role of TA molecules in forming hydrogen bonding with the hydroxyl groups on edge surface of MMT nanosheets. The enhancement mechanism of membrane selectivity via TA modification was attributed to the additional negative charge from TA. The addition of TA enabled efficient PEI monomers adsorption, which can promote the IP reaction and reduce the average pore size. Conductivity test and energy barrier calculations further validated that the TA modification was able to reduce the transport resistance of Li⁺, thus realizing the enrichment of Li⁺.

Key words

montmorillonite / two-dimensional nanosheets / selective membrane / lithium-magnesium separation / tannic acid

引用本文

孙宇鹏, 赵云良, 高仁波, 万骞, 陈立才, 张鑫, 张婷婷. 单宁酸强化二维蒙脱石薄膜锂镁高效分离及其机理. 硅酸盐学报, 2025 , 53 (12) : 3624 -3633 . DOI: 10.14062/j.issn.0454-5648.20250414

Yupeng SUN, Yunliang ZHAO, Renbo GAO, Qian WAN, Licai CHEN, Xin ZHANG, Tingting ZHANG. Enhancement and Mechanism of Tannic Acid Modification on Separation of Lithium and Magnesium in a Two-Dimensional Montmorillonite Membrane[J]. Journal of the Chinese Ceramic Society, 2025 , 53 (12) : 3624 -3633 . DOI: 10.14062/j.issn.0454-5648.20250414

基金

收起

国家重点研发计划青年科学家项目(2022YFC2906300)
国家自然科学基金面上项目(52374275)
湖北省自然科学基金杰出青年项目(2023AFA084)

参考文献

收起

文献

收起

参考文献引证文献

排序方式：

2025年第53卷第12期

PDF下载

引用本文

BibTeX

文章信息

doi: 10.14062/j.issn.0454-5648.20250414

首发时间：2026-10-21
出版时间：2025-12-20

补充材料

相关文章

文章信息

作者

出版历史

修回日期：2025-06-13

基金

国家重点研发计划青年科学家项目(2022YFC2906300)

国家自然科学基金面上项目(52374275)

湖北省自然科学基金杰出青年项目(2023AFA084)

作者信息

^1．武汉理工大学资源与环境工程学院，武汉 430070

^2．武汉科莱烯科技有限公司，武汉 430223

^3．武汉科技大学资源与环境工程学院，武汉 430081

通讯作者:

赵云良（1987—），男，博士，教授。

参考文献

分享链接

https://castjournals.cast.org.cn/joweb/gsyxb/CN/10.14062/j.issn.0454-5648.20250414

分享至

全文二维码

扫描看全文

引用本文

BibTeX

本文的引用情况

2种不同金属材料的力学参数

科 Family	属数 Number of genus	种数 Number of species	占总种数比例 Percentage of total species (%)	属 Genus	种数 Number of species	占总种数比例 Percentage of total species (%)
鹅膏菌科Amanitaceae	2	11	5.26	鹅膏菌属 Amanita	10	4.78
小菇科 Mycenaceae	2	12	5.74	丝盖伞属 Inocybe	5	2.39
多孔菌科 Polyporaceae	8	14	6.70	蜡蘑属 Laccaria	5	2.39
红菇科 Russulaceae	3	23	11.00	小皮伞属 Marasmius	6	2.87
				小菇属 Mycena	11	5.26
				光柄菇属 Pluteus	5	2.39
				红菇属 Russula	17	8.13
				栓菌属 Trametes	5	2.39

关闭全屏

BibTeX
EndNote
RefWorks
TxT