硅酸盐学报

类石墨烯纳米片提升钒基磷酸盐正极储钠性能

PDF下载

邓泽荣 ¹ , 李涛 ² , 丁晓凯 ¹ , 张露露 ¹ , 孙华斌 ³ , 孙畅 ¹ , 杨学林 ¹^,²^,³

硅酸盐学报 | 研究论文 2026,54(5): 1814-1826

收起

硅酸盐学报 |研究论文 2026 , 54 (5) : 1814 -1826

类石墨烯纳米片提升钒基磷酸盐正极储钠性能

全屏

邓泽荣¹, 李涛², 丁晓凯¹, 张露露¹, 孙华斌³, 孙畅¹, 杨学林¹^,²^,³

作者信息

^1．三峡大学电气与新能源学院，湖北省新能源微电网协同创新中心，湖北宜昌 443002

^2．三峡大学分析测试中心，湖北宜昌 443002

^3．三峡大学材料与化工学院，湖北宜昌 443002

通讯作者:

丁晓凯（1990—），男，博士，讲师

张露露（1975—），女，博士，教授

杨学林（1973—），男，博士，教授。

作者简介:

邓泽荣（1999—），男，博士研究生。

Enhanced Sodium Storage Performance of Vanadium-based Phosphate Cathodes via Graphene-like Nanosheets

Zerong DENG¹, Tao LI², Xiaokai DING¹, Lulu ZHANG¹, Huabin SUN³, Chang SUN¹, Xuelin YANG¹^,²^,³

Affiliations

^1.Hubei Provincial Collaborative Innovation Center for New Energy Microgrid, College of Electrical Engineering & New Energy, China Three Gorges University, Yichang 443002, Hubei, China

^2.Analysis and Testing Center of Three Gorges University, Yichang 443002, Hubei, China

^3.College of Materials and Chemical Engineering, China Three Gorges University, Yichang 443002, Hubei, China

Corresponding Author:

DING Xiaokai (1990-), male, Ph.D., Lecturer. E-mail: dingxiaokai@ctgu.edu.cn

ZHANG Lulu (1975-), female, Ph.D., Professor. E-mail: luluzhang@ctgu.edu.cn

YANG Xuelin (1973-), male, Ph.D., Professor. E-mail: xlyang@ctgu.edu.cn

DENG Zerong (1999-), male, Doctoral candidate. E-mail: 15879371289@163.com

出版时间: 2026-04-16 doi: 10.14062/j.issn.0454-5648.20250367

文章导航

摘要

收起

钒基磷酸盐复合材料（VPC）凭借其优异的结构稳定性和灵活的电压可调性，成为钠离子电池正极材料的候选者之一。然而，VPC本征电导率低和离子扩散速率慢等固有缺陷导致VPC存在倍率性能和循环稳定性不足的问题。采用简单的溶胶-凝胶辅助固相法，结合类石墨烯纳米片（GNS）协同改性策略，成功制备了一种由高容量Na₃V₂（PO₄）₂F₃（NVPF）和高稳定性Na₃V₂（PO₄）₃（NVP）组成的新型双相VPC（Bis-VPC）。GNS在Bis-VPC颗粒间构建起三维多孔网络结构，有效抑制了颗粒的无序生长与团聚，同时促进了离子与电子的传输；同时，GNS还通过减少合成过程中的氟损失，实现了NVPF与NVP相比例的调控。优化后的Bis-VPC在0.2 C倍率下表现出118.7 mA·h·g^-1的可逆容量，在20 C高倍率下循环5000次后仍具有90.4%的容量保持率。上述结果揭示了GNS碳材料在调控VPC正极相组成中的关键作用，为设计兼具高倍率和长寿命钠离子电池正极材料提供了新的研究思路。

关键词

钠离子电池 / 正极材料 / 钒基磷酸盐复合材料 / 相组分 / 类石墨烯纳米片

Abstract

收起

Introduction

Vanadium-based phosphate composite (VPC) can be used as a highly promising candidate for sodium-ion battery cathode materials due to its excellent structure stability and flexible voltage adjustability. However, some inherent limitations such as low intrinsic conductivity and low ion diffusion, lead to an inferior rate capability and an insufficient cycle stability in VPC materials. Efforts are dedicated to the improvement of cathode materials, such as bulk structure regulation and surface coating modification. Among them, carbon coating is usually applied to modify the inherently low conductivity of polyanion-type cathodes. The graphitization degree of pyrolytic carbon is restricted due to the limitation of VPC sintering temperature. This restriction results in a marginal enhancement of the electronic conductivity in carbon-coated VPC. To compensate for this deficiency, highly conductive carbon materials such as GO and CNTs are often incorporated into the fabrication process of VPC materials. Nevertheless, the utilization of these carbon materials can lead to a significant increase in production costs. It is thus crucial for improving the conductivity of VPC composite and simultaneously regulating the local electronic structure of vanadium ions to develop carbon materials with high cost-effectiveness and conductivity.

Methods

A certain amount of sodium citrate (Na₃C₆H₅O₇) was subjected to a sintering treatment in N₂ atmosphere at 800 ℃ for 2 h with a heating speed of 5 ℃‧min^-1. After natural cooling, the resultant black powder was then immersed in a dilute solution of HCl (2 mol·L^-1) for 24 h to remove all sodium-containing compounds. Subsequently, graphene-like nanosheets (marked as GNS) as the product were collected via filtering, repeated rinsing with ultrapure water and ethanol, and finally drying at 80 ℃ for overnight.

Vanadium pentoxide (V₂O₅, 1 mmol) and oxalic acid dihydrate (H₂C₂O₄·2H₂O, 2 mmol) were dissolved in 30 mL ultrapure water. After being stirred at 60 ℃ for 30 min, the initially orange turbid solution gradually transformed into a clear green solution. Subsequently, ammonium dihydrogen phosphate (NH₄H₂PO₄, 2 mmol) and sodium fluoride (NaF, 3 mmol) were added into the green solution above. Meanwhile, different specific quantities (i.e., 0.025, 0.033 g and 0.041 g) of GNS powder were individually dispersed into 10 mL ethyl alcohol under ultrasonic agitation for 5 min to obtain a uniform dispersion solution. The green solution was then added to the dispersion solution above. The mixture solution was subjected to continuous stirring at 60 ℃ until the gel was formed. Afterwards, the obtained gel was dried in an oven at 80 ℃ for overnight, and then ground into a fine powder. Finally, the resultant powder was first sintered at 350 ℃ for 5 h and subsequently in N₂ atmosphere at 600 ℃ for 8 h with a heating rate of 3 ℃·min^-1. The vanadium-base phosphate composites prepared with 0.025, 0.033 g and 0.041 g GNS powder were denoted as VPC-GN6, VPC-GN8 and VPC-GN10, respectively. For comparison purpose, a pristine VPC without GNS was prepared by the same method as for GNS modified VPC samples and labeled as P-VPC.

Results and discussion

A novel biphasic-VPC composite (Bis-VPC), composed of high-capacity Na₃V₂(PO₄)₂F₃ (NVPF) and high-stability Na₃V₂(PO₄)₃ (NVP), is effectively prepared by a facile sol-gel assisted solid-state method, and facilitated by the incorporation of GNS. The results obtained from the XRD, XPS and Rietveld refinement demonstrate that the incorporation of an appropriate amount of GNS effectively modulates the content of the NVP phase in VPC composites, while simultaneously broadening the transport channels of Na⁺. Furthermore, The results of Raman spectra, SEM/TEM images, and EIS measurements indicate that GNS can suppress the uncontrolled growth and agglomeration of particles, and facilitate the construction of an efficient ion/electron conductive network. As a result, the electronic conductivity of the optimized sample is significantly enhanced by several orders of magnitude from the 1.25×10^-9 S·cm^-1 to 1.06×10^-4 S·cm^-1. Simultaneously, the VPC-GN8 shows a D_Na+ value of 1.20×10^-12 cm²·s^-1, surpassing that of the P-VPC (5.43×10^-13 cm²·s^-1). The optimized sample also exhibits a high reversible specific capacity of 118.7 mAh·g^-1 at 0.2 C and maintains an excellent capacity retention of 90.4% after 5000 cycles at 20 C. These results indicate that the optimization of phase components through incorporating an appropriate amount of GNS and the construction of highly conductive networks can expand Na⁺ migration channels, facilitate ion and electron transport, and enhance electronic conductivity, thereby improving the durability under high-rate conditions.

Conclusions

In this study, the incorporation of GNS could effectively mitigate the fluorine loss during the synthesis process, thereby facilitating the increase of NVPF phase and improvement of the ionic conductivity of Bis-VPC material. The introduction of GNS constructed an interconnected three-dimensional porous architecture within the matrix of Bis-VPC particles, effectively mitigating the uncontrolled growth and agglomeration of particles and accelerating the transport of both ions and electrons. In addition, the generated porous structure also increased the interface between Bis-VPC particles and electrolyte. Consequently, the modified sample exhibited improved reversible capacity, exceptional rate performance and ultra-long cycle life. This novel modification strategy, which enhanced ion and electronic conductivity through graphene like nanosheets, could accelerate the application of high-energy-density vanadium-based phosphate cathode materials in large-scale energy storage for SIBs.

Key words

Na ion batteries / cathode materials / vanadium-based phosphate composite / phase composition / graphene-like nanosheets

引用本文

邓泽荣, 李涛, 丁晓凯, 张露露, 孙华斌, 孙畅, 杨学林. 类石墨烯纳米片提升钒基磷酸盐正极储钠性能. 硅酸盐学报, 2026 , 54 (5) : 1814 -1826 . DOI: 10.14062/j.issn.0454-5648.20250367

Zerong DENG, Tao LI, Xiaokai DING, Lulu ZHANG, Huabin SUN, Chang SUN, Xuelin YANG. Enhanced Sodium Storage Performance of Vanadium-based Phosphate Cathodes via Graphene-like Nanosheets[J]. Journal of the Chinese Ceramic Society, 2026 , 54 (5) : 1814 -1826 . DOI: 10.14062/j.issn.0454-5648.20250367

基金

收起

国家科技重大专项项目(2022YFB3807700)
国家自然科学基金项目(52072217)
湖北省自然科学基金创新与发展联合基金项目(2022CFD034)
湖北省自然科学基金项目(2024AFB295)
湖北省自然科学基金创新团体项目(2022CFA020)
湖北省科技厅重大科技创新项目(2019AAA164)

参考文献

收起

文献

收起

参考文献引证文献

排序方式：

2026年第54卷第5期

PDF下载

119

引用本文

BibTeX

文章信息

doi: 10.14062/j.issn.0454-5648.20250367

接收时间：2025-05-07
首发时间：2026-09-20
出版时间：2026-04-16

补充材料

相关文章

文章信息

作者

出版历史

收稿日期：2025-05-07
修回日期：2025-06-20

基金

国家科技重大专项项目(2022YFB3807700)

国家自然科学基金项目(52072217)

湖北省自然科学基金创新与发展联合基金项目(2022CFD034)

湖北省自然科学基金项目(2024AFB295)

湖北省自然科学基金创新团体项目(2022CFA020)

湖北省科技厅重大科技创新项目(2019AAA164)

作者信息

^1．三峡大学电气与新能源学院，湖北省新能源微电网协同创新中心，湖北宜昌 443002

^2．三峡大学分析测试中心，湖北宜昌 443002

^3．三峡大学材料与化工学院，湖北宜昌 443002

通讯作者:

丁晓凯（1990—），男，博士，讲师

张露露（1975—），女，博士，教授

杨学林（1973—），男，博士，教授。

参考文献

分享链接

https://castjournals.cast.org.cn/joweb/gsyxb/CN/10.14062/j.issn.0454-5648.20250367

分享至

全文二维码

扫描看全文

引用本文

BibTeX

本文的引用情况

2种不同金属材料的力学参数

科 Family	属数 Number of genus	种数 Number of species	占总种数比例 Percentage of total species (%)	属 Genus	种数 Number of species	占总种数比例 Percentage of total species (%)
鹅膏菌科Amanitaceae	2	11	5.26	鹅膏菌属 Amanita	10	4.78
小菇科 Mycenaceae	2	12	5.74	丝盖伞属 Inocybe	5	2.39
多孔菌科 Polyporaceae	8	14	6.70	蜡蘑属 Laccaria	5	2.39
红菇科 Russulaceae	3	23	11.00	小皮伞属 Marasmius	6	2.87
				小菇属 Mycena	11	5.26
				光柄菇属 Pluteus	5	2.39
				红菇属 Russula	17	8.13
				栓菌属 Trametes	5	2.39

关闭全屏

BibTeX
EndNote
RefWorks
TxT